Инструкции по ремонту BMW i3 2014-2019MY

Для администрации D2: Все инструкции скачаны с сайта Национального управления безопасностью движения на трассах и находятся там в свободном и бесплатном доступе! Я всего лишь упорядочил и систематизировал.

Список постоянно пополняется. Со временем добавлю все ссылки.

Service Information (Сев. Америка):

B12 12 19 Safety Recall 19V-310: Electric Motor Electronics (EME) ❗
B12 01 18 EME FAULTS CANNOT BE READ IN ISTA
B12 25 17 PROGRAM CONTROL UNITS (EME)
B12 29 16 SERVICE ENGINE SOON (MIL) – RDME FC 124301/124302
B12 27 15 Service Engine Soon (MIL) – IHKA FC 801375 & 8013A3
B12 21 16 SERVICE ENGINE SOON (MIL) — IHKA FC 8013A3
B12 03 16 EME No Longer Communicates after HV Charging
B12 38 15 Various Software Fixes and Improvements ❗
B12 34 15 Service Engine Soon (MIL) – RDME FC 128002
B12 30 15 EME Fault Code: 222011
B12 28 15 EME Fault Code: 2228BF
B12 20 15 Service Engine Soon (MIL): RDME FC 120006
B12 12 15 Service Engine Soon (MIL): EME FC CF948C
B12 32 14 Service Engine Soon (MIL) Lamp Illuminated with No Relevant Faults
B12 16 14 Customer Care Package Software Update ❗
B12 11 14 Customer Care Package: Software Update
B12 10 14 Check Engine Lamp On with No Relevant Faults Stored
B12 09 14 Fault Code 121001 Stored in RDME
B12 08 14 Fault Code 222717 Stored in EME ❗

B61 04 18 EME SETS FAULT CODE 222931 OR LOW COST CHARGING NOT FUNCTIONAL AFTER PROGRAMMING
B61 10 18 THE DISPLAY GOES BLACK, VEHICLE DOESN’T START AGAIN AFTER SWITCHING THE ENGINE OFF
B61 16 17 CHARGING SOCKET EMERGENCY RELEASE DAMAGED
B61 07 17 CCM OR MIL DISPLAYED AFTER DC CHARGING
B61 10 17 SME FAULT CODE 21F0D2
B61 15 17 PROGRAMMING CONTROL MODULES FOR OBD COMPLIANCE
B61 26 17 CHARGING NOT POSSIBLE AFTER DIAGNOSTIC OR PROGRAMMING SESSION
B61 41 17 END OF SERVICE (EOS) TEST FAILS
B61 42 17 MIL ACTIVATED AFTER DC CHARGING – LIM FC 805526
B61 43 17 EME FAULT CODES S0728 S0729
B61 46 17 LACK OF POWER OR DRIVING READINESS CANNOT BE ESTABLISHED
B61 11 16 THE CHARGING CABLE DOES NOT RELEASE FROM THE CHARGING SOCKET AFTER CHARGING ❗
B61 20 16 POWER LOSS AT VERY LOW SOC OF HV BATTERY
B61 22 16 SME FC 21F284 “HIGH-VOLTAGE BATTERY UNIT, CELL SUPERVISION CIRCUIT: SAFETY CIRCUIT ACTIVATED”
B61 02 16 CSC Communication Errors
B61 03 16 SME Fault Code 21F0D2 Causes Erroneous CCM
B61 04 16 EME Fault Code 222C02 Following Replacement or Programming- Diagnosis
B61 08 16 DC-DC Converter does not supply sufficient 12V power
B61 11 16 The Charging Cable Does not Release from the Charging Socket after Charging
B61 12 16 DC Charging – Customer Focused Diagnosis
B61 15 16 CCM CHARGING NO LONGER POSSIBLE DURING OR AFTER TRANSPORT MODE
B61 17 16 SERVICE ENGINE SOON (MIL) — SME FC 21F0D0
B61 20 16 POWER LOSS AT VERY LOW SOC OF HV BATTERY
B61 21 16 PROGRAMMING CONTROL UNITS (RANGE)
B61 29 16 MIL LAMP ILLUMINATED — EME FAULT CODES 222705, 222710, 222712, 222719, 22272C OR 22272D
B61 08 15 High-Voltage Charging Cable Lock Malfunction
B61 19 15 Grating or Scraping Noise When Turning Steering Wheel
B61 01 15 Discharged 12V Battery
B61 02 15 Clicking Noise from Off-board Charger
B61 05 15 12-volt Battery Terminal Adapter Slightly Loose
B61 07 15 Charging Stops when Using “Occasional Use” Cable
B61 08 15 High-Voltage Charging Cable Lock Malfunction
B61 18 15 Charging is not Possible, or is Reduced
B61 19 15 Grating or Scraping Noise When Turning Steering Wheel
B61 16 14 HV Battery — End of Service Test Failed
B61 09 14 High-voltage Battery Charging Recommendations
B61 10 14 Fault Code 21F046 Stored in SME
B61 23 14 The Start-Stop Button Must Be Pressed Several Times to Stop Engine
B61 27 14 Low Cost Charging Functionality
B61 28 14 Charging Concerns
B61 29 14 High-Voltage Battery Stops Charging
B61 31 14 Replace Convenience Charging Electronics (KLE)
B61 35 14 Displayed Range Is Lower After Programming
B61 36 14 High Voltage Isolation Fault Code Troubleshooting
B61 38 14 Drivetrain Malfunction (CCM 794) with Isolation Faults
B61 39 14 12V Battery Discharge Message (CCM 794) After Charging

B64 04 19 INTERMITTENT HEATER OUTPUT ❗
B64 13 18 INSUFFICENT AIR COMING FROM VENTS
B64 11 18 STATIONARY CLIMATE CONTROL NOT WORKING AFTER HIGH VOLTAGE CHARGING
B64 07 18 STATIONARY CLIMATE CONTROL NOT POSSIBLE WHEN SET FOR DEPARTURE TIME BETWEEN 0-00 AND 0-30 TIME
B64 08 16 Reduced or No HVAC Heat Output
B64 10 16 KNOCKING NOISE FROM RF WHEEL AREA WHEN A/C IS ACTIVATED
B64 13 16 A/C FAILURE: FC 801252 ELECTRIC A/C COMPRESSOR: INTERNAL FAULT DETECTED

B22 01 16 Replace the Motor Mount Screws ❗
B22 04 15 Replace the Motor Mount Screws
B22 01 15 Left Side Engine Mount Broken

B31 01 18 NOISE FROM FRONT AXLE WHEN STEERING
B31 06 14 Front Axle Noise when Turning at Low Ambient Temperatures

B32 04 15 Steering wheel rubs/brushes against the steering column trim
B32 03 15 NOISES WHEN TURNING THE STEERING WHEEL
B32 07 14 Sporadic Electronic Power Steering (EPS) Warning Lamp when Starting Drive Readiness
B32 06 14 Noises and/or Play Around Steering Column ❗
B32 05 14 Steering Wheel Does Not Return to Center ❗
B32 02 14 POWER-ASSISTED STEERING INTERMITTENTLY NOT AVAILABLE AT ENGINE START-UP ❗

B34 07 19 CHECK CONTROL MESSAGE (CCM) “BRAKE SYSTEM” DISPLAYED
B34 02 14 Noises when Braking

B65 12 18 AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT
B65 18 16 AIRBAG WARNING LAMP ILLUMINATED
B65 05 16 False Alarms of the Anti-Theft Alarm System
B65 27 16 SOFTWARE CHANGES AFTER PROGRAMMING WITH ISTAP V3.59.2
B65 03 15 Airbag Warning Light ON — Fault 930BE3, High-voltage System Shutdown ❗
B65 07 15 Airbag Warning Light ON — Fault 930BE8, High-voltage System Shutdown ❗
B65 26 15 Hissing Noise from Speakers when Radio Volume is Turned Down
B65 13 14 i3 Business Navigation – Retrofit

B51 33 19 INSPECT REAR WINDOW
B51 19 19 SQUEAKING NOISE WHEN OPERATING THE SIDE WINDOWS
B51 16 19 OUTER DOOR HANDLE LOOSE
B51 18 16 INSTRUMENT PANEL TRIM FADING
B51 14 15 Grinding Noise from Steering Wheel When Turning
B51 05 15 Groaning Noise when Opening and Closing Rear Doors
B51 12 15 Front Door Trim Panel Loose
B51 18 15 A Check Control Message is displayed for the Tailgate Lock Open
B51 20 14 Driver's Footwell Trim Rattles
B51 21 14 Front Door Makes Rattling Noise
B51 27 14 Retighten Bolts in Door Brake

B54 02 19 RATTLE NOISE IN SUNROOF AT HIGH TEMPERATURES
B54 01 16 Sunroof – Possible Leak

B11 20 16 I3 REX — W20 ENGINE OIL SERVICE PROCEDURE

B16 03 18 SERVICE ACTION REPLACE THE FUEL TANK PRESSURE TEMPERATURE SENSOR
B16 12 14 Replace Fuel Tank Pressure Sensor

B17 04 16 CHECK CONTROL MESSAGE: “DRIVETRAIN: ONLY ELECTRIC DRIVE POSSIBLE”

B18 01 16 Correct Installation of W20 Catalytic Converter

B27 01 15 Replace Park Lock Actuator
B27 01 14 Parking Lock Cannot Be Engaged or Disengaged

B36 04 14 Rolling Tire Noise

B62 11 17 INSTRUMENT CLUSTER HAZES OVER
B62 02 16 CBS Incorrect After Instrument Cluster Replacement

B63 04 15 Traces of Condensation Appear in Rear Tailgate Lights

B66 01 18 REMOTE KEY WILL NOT OPEN OR START VEHICLE
B66 04 16 “Comfort Access Restricted” Check Control Message is Displayed
B66 08 15 Comfort Access Does Not Function After Vehicle Enters Sleep Mode

B71 01 15 Voluntary Emissions Recall Campaign 15E-A01 — Retrofit Emissions Label for I01 and I12

B01 13 18 X5 PHEV, I3 REX AND I8 FUEL TANK PRESSURE SENSOR — LIMITED WARRANTY EXTENSION TO 10 YEARS 120,000 MILES
B01 21 14 BMW i Charging Station-Wallbox — Limited (Parts) Warranty Policy, Procedures and Servicing

B00 06 14 BMW Early Warning Information Program